Product ID:PENAIR C-5575 EXTERIOR AIRCRAFT CLEANER
MSDS Date:12/12/1996
FSC:6850
NIIN:01-248-9831
MSDS Number: CHHSK

PENETONE CORP SUB OF WEST CHEMICAL PRODUCTS INC

74 HUDSON AVENUE
TENAFLY, NJ 07670-1017
US

Emergency Phone: 201-569-5340

Info Phone: 201-567-3000

Cage: 56883

PENETONE CORP

TENAFLY, NJ 07670 US

Telephone: 201-567-3000

Cage: 56883

PETROLEUM HYDROCARBON,

CAS: 64742-47-8

RTECS: OA5504000

D-LIMONENE

CAS: 5989-27-5

RTECS: GW6360000

WATER

CAS: 7732-18-5

RTECS: ZC0110000

SURFACTANTS (MIXTURE-ANIONIC & NONIONIC)

DIETHYLENE GLYCOL MONOBUTYL ETHER

CAS: 112-34-5

RTECS: KJ9100000

Fraction By Weight: <5%

LD50 LC50 Mixture:NOT GIVEN FOR PRODUCT AS A WHOLE
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT SLIGHTLY IRRITATING. HIGH
VAPOR CONCENTRATIONS MAY BE IRRITATING TO EYES. FREQUENT OR
PROLONGED CONTACT MAY IRRITATE OR DRY SKIN & CAUSE DERMATITIS. HIGH
VAPOR CONCENTRATIONS ARE IRRITATIN G TO RESPIRATORY TRACT & MAY
CAUSE CNS EFFECTS. SMALL AMOUNTS DRAWN INTO LUNGS MAY CAUSE SEVERE
& DELAYED EFFECTS.
Explanation of Carcinogenicity:THIS COMPOUND CONTAINS NO INGREDIENTS AT
CONCENTRATIONS OF 0.1% OR GREATER THAT ARE CARCINOGENS OR SUSPECT
CARCINOGENS.
Effects of Overexposure:EYE IRRITATION, SKIN IRRITATION, DERMATITIS,
RESPIRATORY TRACT IRRITATION, HEADACHES, DIZZINESS, ANESTHESIA,
DROWSINESS, UNCONSCIOUSNESS, CNS EFFECTS, INFLAMMATION OF LUNGS,
INFECTION OF BRONCHI, DIGE STIVE TRACT IRRITATION, DIRRHEA.
Medical Cond Aggravated by Exposure:SKIN CONTACT MAY AGGRAVATE AN
EXISTING DERMATITIS CONDITION.

First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING.
WASH WITH SOAP AND WATER. IF IRRITATION PERSIST, GET MEDICAL
ATTENTION. INH ALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. GET
MEDICAL ATTENTION. INGESTION: DO NOT INDUCE VOMITING. USE A STOMACH
PUMP. CALL A PHYSICIAN IMMEDIATELY.

Flash Point Method:TCC
Flash Point:145F,63C
Lower Limits:NOT GIVEN
Upper Limits:NOT GIVEN
Extinguishing Media:EITHER ALLOW FIRE TO BURN OUT UNDER CONTROLLED
CONDITIONS OR EXTINGUISH WITH WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:FIRE FIGHTERS SHOULD WEAR SELF CONTAINED
BREATHING APPARATUS AND FULL PROTECTIVE GEAR.
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID. CAN FORM COMBUSTIBLE
MIXTURES AT OR ABOVE FLASH POINT. CONTAINERS CAN RUPTURE AND
EXPLODE UNER FIRE CONDITIONS DUE TO PRESSURE BUILDUP.

Spill Release Procedures:ELIMINATE SOURCES OF IGNITION. USE ABSORBENT
MATERIAL TO COLLECT AND PUT ALL MATERIAL INTO PROPER WASTE DISPOSAL
CONTAINER WITH LID TIGHTLY COVERED. RINSE AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE ABOVE 120F. KEEP FROM
FREEZING. KEEP AWAY FROM HEAT SOURCES, OPEN FLAMES, IGNITION
SOURCES. DO NOT STORE NEAR STRONG OXIDIZERS.
Other Precautions:AVOID BREATHING OF VAPORS AND SPRAY MIST. USE WITH
ADEQUATE VENTILATION. DO NOT FOG. AVOID CONTACT WITH SKIN, EYES &
CLOTHING.

Respiratory Protection:IF SPRAYING, WEAR A PARTICLE MASK.
Ventilation:LOCAL EXHAUST AND MECHANICAL (GENERAL) VENTILATION AS
REQUIRED TO MAINTAIN EXPOSURE LEVELS.
Protective Gloves:SOLVENT RESISTANT
Eye Protection:SAFETY GLASSES
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:WASH HANDS THOROUGHLY WITH SOAP AND WATER
BEFORE EATING, DRINKING, SMOKING OR USING TOILET FACILITIES.
Supplemental Safety and Health
ASPIRATION HAZARD.

HCC:V4
Boiling Pt:B.P. Text:212F,100C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Decomp Temp:Decomp Text:NOT GIVEN
Vapor Pres:= WATER
Vapor Density:NOT GIVEN
Spec Gravity:1.0
pH:8-9
Viscosity:NOT GIVEN
Evaporation Rate & Reference:< 0.05(BUTYL ACETATE=1)
Solubility in Water:EMULSIFIES
Appearance and Odor:CLEAR, YELLOW-ORANGE VISCOUS LIQUID WITH A MILD
CITRUS ODOR
Percent Volatiles by Volume:20 %

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:DO NOT STORE ABOVE 120F. KEEP FROM
FREEZING.
Hazardous Decomposition Products:SMOKE, FUMES AND OXIDES OF CARBON.

Waste Disposal Methods:PREVENT WASTE FROM CONTAMINATING SURROUNDING
ENVIRONMENT. DISCARD ANY PRODUCT, RESIDUE, DISPOSAL CONTAINER OR
LINER IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.